Surplus Generation Equipment |
Surplus Generation Equipment, LLC, Brokering the following surplus equipment: Natural gas generator, nat gas generator, micon wind turbine, Gas Turbine, Frame 3 Turbine, Frame 5 Turbine, Frame 7 Turbine, Frame 9 Turbine, 7ea Turbine, 7fa Turbine, LM2500 Turbine, LM5000 Turbine, LM6000 Turbine, Siemens 501 Turbine, GE Turbine, Alstom Turbine, Solar Turbine, Rolls Royce Turbine, Mitsubishi Turbine, Westinghouse Turbine, Solar Taurus Turbine, Solar Mars Turbine, Solar Centaur Turbine, Solar Tornado Turbine, Steam Turbine, Gas Turbine, Used Steam Turbine, Surplus Steam Turbine, Used Gas Turbine, Surplus Gas Turbine, Simple Cycle Turbine, 10MW Turbine Generator, 20MW Turbine Generator, 30MW Turbine Generator, 40MW Turbine Generator, 50MW Turbine Generator, 60MW Turbine Generator, 70MW Turbine Generator, 80MW Turbine Generator, Warstsila, Caterpillar, Diesel Generator, Diesel Genset, Natural Gas Generator, Natgas Generator, Natgas genset, Jenbacher, Jenbacker, Cooper, Cooper Superior, Compressor, Cooling Tower, Wind Turbine, Micon, Micon Wind Turbine, Vestas, Vestas Wind Turbine, Deutz, Deutz generator, Used Wind Turbine, Used Diesel Generator, Wartsila |
Two (2) MITSUBISHI Model RM 500G - GS12A2-PTK NATURAL GAS GENERATOR SETS Enclosed Units 500 KW Each Continuous duty 1 MW Total 480 volts 60 HZ 1,012 & 908 Total Run Hours OVERALL DIMENSIONS : LENGTH 150 INCHES, WIDTH 60 INCHES, HEIGHT 75 INCHES, DRY WEIGHT 15,500 POUNDS PERFORMANCE CHARACTERISTICS Standard generator sets have high performance components to meet the toughest applications. 500 KW Each Continuous duty for unlimited hours per year and 100% load factor Newage Stamford generator ends model HC534F with MX321 voltage regulators - PRECISE VOLTAGE REGULATION + ½ % Steady State + 1 % from no load to full load - PRECISE FREQUENCY CONTROL The Woodward electronic isochronous governor has 0% droop, no load to full load, and 1/4 % steady state. - PERMANENT MAGNET EXCITATION Provides excellent performance with heavy SCR loads. 300% full load current available for 10 seconds during short circuit condition. - HIGH MOTOR STARTING CAPACITY 250% of rated capacity for 10 seconds. - LOW EMISSIONS The Mitsubishi LeanBurn engine has low emissions without any after treatment. CLEAN EXHAUST EMISSIONS: Emissions G/bhp NOx .7 CO .5 NMHC .2 EXCELLENT FUEL EFFICIENCY: Fuel Consumption 6800 BTU/hphr, At 100% load based on L. H. V. Natural Gas Supply Requirements* Gas Use Pressure (psi) % of Total Gas Main gas .2 to 3 85% Pre-chamber gas 25 to 28 15% *Requires a maximum of 5 million BTU/hr. of pipeline quality gas at 1040 BTU/CF ± 5%. - PARALLELING OPTIONS Controls can be added for completely automatic. VOLTAGE RANGE 3 WIRE 416 - 480 208 - 240 60HZ ----------------------------------------- 4 WIRE 240/416 - 277/480 120/208 - 138/240 GENERATOR SET SPECIFICATIONS 60 HZ - 100% loaded Model RM500G KW 500 KVA 625 HP 710 BMEP 152 psi Heat rejection to jacket water 15600 BTU/min Heat rejection to ambient 5500 BTU/min. Jacket water temperature 190 to 205º F Exhaust temperature 850º F Heat rejection to intercooler 5050 BTU/min Exhaust gas flow 1820 SCFM Combustion air flow 1736 CFM Jacket water coolant flow 291 GPM NATURAL GAS ENGINE Mitsubishi GS12A2-PTK Type 4 cycle, water-cooled, turbocharged, intercooled with raw water Combustion chamber Ultra LeanBurn with pre-chamber ignition Compression ratio 11.5:1 Engine speed 1800 RPM Cylinder arrangement 60 degree vee 12 cylinder Displacement 2070 cubic inch bore, 5.91 stroke. 6.3 Exhaust flex diameter 8 inches (inside) Muffler diameter 10 inches (inside) Maximum exhaust back pressure 23.6 inches of water I tltit M I 90º F t 53 GPM STANDARD EQUIPMENT - Mitsubishi GS12A2-PTK natural gas engine - Newage Stamford generator (HC534F) rated for 80º C rise with 3 phase static voltage regulator (MX321) and permanent magnetic excitation. All rated per NEMA Code. - Heavy duty structural steel subbase - Woodward isochronous governor and air/fuel controller - Free standing control panel with: Altronic CPU95 ignition system, automatic start/stop control, gauges for oil pressure, cylinder temp., battery voltage, water temp., running hours, AC amps, AC volts, frequency, KW, KVA, and power factor - 24 volt automatic electric start system - 20 amp battery charger - Engine safety switches & Pre-alarms: low oil pressure, high water temperature, overspeed, overcrank, high exhaust temperature, low gas pressure, ignition fault - Residential silencer with stainless steel flexible connection - 24 volt lead acid battery, rack and cables - Flexible fuel lines - Catalytic convertor for CO and NMHC - Local computer with 6 screens for real time and historical data display - Remote telephone access to local computer |